Author Topic: smoking belt  (Read 978 times)

Offline superfox

  • Trade Count: (0)
  • 6x6'er
  • **
  • Posts: 58
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #17 on: October 02, 2017, 08:43:30 PM »
I will drain it this week its almost like forward and reverse are both in

Offline wedge

  • Trade Count: (2)
  • Master 6x6'er
  • *****
  • Posts: 1339
  • Country: us
  • Karma: +0/-0
  • Run it like a Big Block !
Re: smoking belt
« Reply #16 on: October 01, 2017, 06:47:04 PM »
you Drain the fluid and it will tell you quick !
3, Amphicat. 1, StarCraft. 1, Max 2 And Counting

Offline superfox

  • Trade Count: (0)
  • 6x6'er
  • **
  • Posts: 58
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #15 on: October 01, 2017, 06:46:23 PM »
right side works as should but sloppy left was binding up but now grinding both ways and you can watch the shaft move a good bit. just an old diesel mechanic but I know that much in a box aint good
« Last Edit: October 01, 2017, 06:50:05 PM by superfox »

Offline superfox

  • Trade Count: (0)
  • 6x6'er
  • **
  • Posts: 58
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #14 on: October 01, 2017, 06:42:06 PM »
over an inch

Offline superfox

  • Trade Count: (0)
  • 6x6'er
  • **
  • Posts: 58
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #13 on: October 01, 2017, 06:40:12 PM »
just tied it again the left side is grinding and wont move looks like a rebuild on the 20

Offline wedge

  • Trade Count: (2)
  • Master 6x6'er
  • *****
  • Posts: 1339
  • Country: us
  • Karma: +0/-0
  • Run it like a Big Block !
Re: smoking belt
« Reply #12 on: October 01, 2017, 06:31:23 PM »
It will have some movement but Not A lot.
Sounds to me like a Bind somewhere ?
But Hard to say with out seeing t ??
Best thing to do is start from Point A to point G on the drive system.
If the Engine mounts are god as WFO said then look at the Drive clutch. Then to the Driven Then Tranny.
Then the Main drive an so on.
You will find the Problem for sure !
3, Amphicat. 1, StarCraft. 1, Max 2 And Counting

Offline WFO

  • Trade Count: (0)
  • Sr. 6x6'er
  • ****
  • Posts: 430
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #11 on: October 01, 2017, 06:31:16 PM »
I did notice the driven clutch shaft moving in and out of the t20, cant be good
how far, in and out should be no more than about 1/8 inch
"94" MAX IV SPRINGER & ULTIMATE BEARINGS
BE JUDGED BY YOUR CHARACTER

Offline superfox

  • Trade Count: (0)
  • 6x6'er
  • **
  • Posts: 58
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #10 on: October 01, 2017, 06:28:28 PM »
see smell and taste

Offline superfox

  • Trade Count: (0)
  • 6x6'er
  • **
  • Posts: 58
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #9 on: October 01, 2017, 06:26:51 PM »
I got it apart, moving out the way with 1 axle out

Offline superfox

  • Trade Count: (0)
  • 6x6'er
  • **
  • Posts: 58
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #8 on: October 01, 2017, 06:24:56 PM »
I did notice the driven clutch shaft moving in and out of the t20, cant be good

Offline WFO

  • Trade Count: (0)
  • Sr. 6x6'er
  • ****
  • Posts: 430
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #7 on: October 01, 2017, 06:24:23 PM »
how do you know the belt is smoking, can you see it or smell it. or IS IT THE TRANS ?
"94" MAX IV SPRINGER & ULTIMATE BEARINGS
BE JUDGED BY YOUR CHARACTER

Offline superfox

  • Trade Count: (0)
  • 6x6'er
  • **
  • Posts: 58
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #6 on: October 01, 2017, 06:20:58 PM »
the brakes are acting crazy too. sticks seem looser

Offline WFO

  • Trade Count: (0)
  • Sr. 6x6'er
  • ****
  • Posts: 430
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #5 on: October 01, 2017, 06:19:13 PM »
Had that happen one time, the engine mounts broke on the opposite side of the clutch lifting the motor when under load.
"94" MAX IV SPRINGER & ULTIMATE BEARINGS
BE JUDGED BY YOUR CHARACTER

Offline wedge

  • Trade Count: (2)
  • Master 6x6'er
  • *****
  • Posts: 1339
  • Country: us
  • Karma: +0/-0
  • Run it like a Big Block !
Re: smoking belt
« Reply #4 on: October 01, 2017, 06:17:21 PM »
Did you Check your Tranny Fluid ?
I would look at it to make sure your T20 is in good shape First !
Then make sur the rest of you drive system is working rite !?!??
3, Amphicat. 1, StarCraft. 1, Max 2 And Counting

Offline superfox

  • Trade Count: (0)
  • 6x6'er
  • **
  • Posts: 58
  • Country: us
  • Karma: +0/-0
Re: smoking belt
« Reply #3 on: October 01, 2017, 06:13:14 PM »
no it did good about 2 months ago when I broke an axle